2021 Volvo XC40 Recharge / EX40 problems & recalls

Jul 30, 2025Electrical system, Visibility/wiper

1. OBC failure. Stranded unable to charge. Situational could be dangerous. 2. Rt side mirror defaults to extreme angle after locking car evert time. Dealership could not troubleshoot solution.

Jul 16, 2025Fuel/propulsion system

I was driving this car on Highway 99 on 7/11/2025. The dashboard flashed the message " Stop safely The vehicle will stop Propulsion system failure." I cut the lane and stopped my car on the Highway 99 shoulder. Just right, my car stopped on the Highway shoulder; it disabled itself and couldn't move at all. The gear shift can't shift to neutral (N). From the first message appearing on the dashboard to the car being disabled takes just a couple of seconds. When it happened, it was about 6:30 pm, rush hour. If I had not had a chance to drive the car immediately to the highway shoulder, the vehicl…

Jul 1, 2025Back over prevention

The contact owns a 2021 Volvo XC40. The contact stated that while reversing, the back over prevention screen image malfunctioned and started flickering before displaying a blank screen. During the failure, the message "Camera Unavailable" was displayed. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was recently repaired under NHTSA Campaign Number: 25V282000 (BACK OVER PREVENTION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage…

May 30, 2025Back over prevention

After having the rear camera software update to address the safety recall on 05/28, the “camera unavailable” problem persists. This vehicle has underpowered chipset in the IHU and the entire IHU should be subject to recall.

May 21, 2025Electrical system

Turning out of parking lot , car started pulsing, and stopped. Propulsion failure box popped up. Thankfully no cars behind us (young daughter in car seat)or was not attempting to merge on highway. Tow truck manually pulled car as no electric (cannot unlock or open trunk), completely shut down.

Jan 4, 2025Electrical system

The 12-volt battery has failed on 5 occasions. Each time, I tried to unlock the vehicle after being away from it for a short period (e.g., 5-40 minutes). I had to use the manual key to unlock the vehicle, but the vehicle wouldn't start. I had the vehicle towed 4 times. One time it started on its own. I have taken the vehicle to my Volvo dealership 3 times for this issue. The most recent time this happened the dealership instructed me to have Volvo Roadside Assistance tow the vehicle to the dealership, even though the vehicle was 91 miles from the dealership. The tow operator confirmed to me t…

Oct 30, 2024Electrical system, Engine

The check engine light has been on my vehicle since April 1, 2024. I have taken it in twice to a Volvo dealership and they cannot give me an answer as to why this is happening. They reset it and it comes right back on after a few miles. They tell me when they get an answer they will call me back in to have it fixed. It still has not been fixed.

Jul 21, 2024Vehicle speed control⚠ Crash

Car can move forward automatically itself from stop position