What owners reported to NHTSA, by component. One complaint can name several components.
Sep 11, 2026Exterior lighting
Component that failed: Vehicle headlight/running light has water penetration and the running lights do not stay on. Additionally there is yellowing of the LED running lights, which is a known defect in the Kia EV6. Safety issue: Running lights reduced night time illumination and made it more difficult to see road. Running lights yellowing are a sign of premature failure. Dealer inspection: Dealer identified problem during a state inspection (light turned off after a few seconds). Vehicle headlights have three issues: 1. Yellowing of LED running lights, 2. Failure of seals allowing water…
Sep 8, 2026Electrical system
The ICCU, or integrated charge control unit, continually fails on this car. When it fails, the 12V battery rapidly drains and the car goes into turtle mode (25mph max) until the 12 battery drains completely. This has happened 4 times on this car, twice since I purchased it 'certified pre-owned" from a Kia dealership in February 2026. Luckily for me the two times it has failed on me, I was in town and close to home. I purchased this car to use for road trips, and out in remote areas of wilderness that do not have cell reception. It is my opinion that the lack of a permanent fix from Kia is a…
Aug 13, 2026Electrical system
I began to drive. The dashboard display read "Check low voltage supply" or something like that and on the opposite side of the display there was a small image that looks like a 12V battery. A moment later the dashboard display changed to read "DO NOT DRIVE." The car was towed to a dealer who reported a "failed ICCU and High Voltage Fuse." The vehicle was towed to a dealership where it is being repaired under warranty. The same parts were replaced on December 26, 2024, that time because the electric vehicle would no longer accept a charge from a 240VAC source, although it continued accept a ch…
Jul 29, 2026Exterior lighting
The taillight came loose and every time i take it in to get checked or fixed at the dealer they ignore me, so i went in and tightened my self. there were 4 nuts already off and inside my trunk and there was no loctite on the bolts holding the light on. now the lamp is leaking water into the trunk and the tail light has water inside of it.
Jul 28, 2026Electrical system, Engine
Vehicle Safety Complaint My Kia experienced an ICCU (Integrated Charging Control Unit) failure and was at the dealership for approximately two months while awaiting repairs. The ICCU and related components were replaced, and I was told the vehicle had been repaired. However, immediately after I received the vehicle back, the “Check Electric Vehicle System” warning illuminated again. Since that time, the vehicle has continued to experience serious electrical issues. The vehicle has unexpectedly shut off while stopped at red lights and has failed to restart on multiple occasions, leaving me s…
Jul 27, 2026Structure
The front lower air dam and felt underguard detached while driving at highway speed on an interstate. The panel dropped and dragged on the pavement. I secured it with duct tape and zip ties at the roadside in order to drive home. There was no collision and no impact with road debris. The bumper fascia directly above the panel is undamaged, with no deformation and no paint transfer, which is not consistent with an impact and is consistent with failure of the panel's mounting fasteners. The panel shows longitudinal drag scoring on the underside and outward flex-fracture of the mounting clips. Th…
Jul 4, 2026Electrical system, Unknown or other
1. Severe Safety Concerns (Battery Thermal Risk & Component Interdependency) The PTC (Positive Temperature Coefficient) heater in my vehicle has failed. This component failure has completely disabled my vehicle’s air conditioning (AC) system. In the Kia EV6 architecture, the AC compressor loop is not merely a cabin comfort feature; it is intrinsically linked to the vehicle's thermal management system responsible for cooling the high-voltage traction battery pack. California temperatures are projected to hit 110°F immediately. Without a functioning AC system, the vehicle cannot execute critical…
Jun 30, 2026Electrical system
ICCU failure caused charger circuit breaker to trip due to sudden fault current situation