What owners reported to NHTSA, by component. One complaint can name several components.
Sep 27, 2026Electrical system, Vehicle speed control, Engine
Dear Kia Customer Care, I am writing to formally report a serious and recurring safety issue with my Kia vehicle. I have repeatedly experienced a "Power Limited" error while driving, often accompanied by a turtle icon and a "Check Electric Vehicle System" warning. On multiple occasions, the vehicle has suddenly lost power and stalled in the middle of the road. This is extremely dangerous and has put me and other drivers at risk. A vehicle should never lose propulsion unexpectedly, especially in active traffic conditions. I request an immediate investigation into this issue, along with a cle…
Sep 26, 2026Electrical system⚠ Fire
I was driving my car on the highway, then I got the message çheck your electrical system'for around a minute. Then there was a rumble or bang as if I hit something with the back, but the road was clean. Then the car started slowing down and I drove to the side. I got out of the car and saw white smoke coming from under the car in the back. I started opening the hood and trunk in the back to find out, where the smoke came from. It was nothing to see. Because it was an electrical car I assumed, that it could start burning, when it smells like smoke and looks like smoke. So I called 911 and told…
Sep 9, 2026Steering, Service brakes, Forward collision avoidance
I got into my car in a hurry i put my car in drive as i was closing my driver's door and took off and because the door wasn't fully closed the parking brake engaged itself but the power over comes the parking brake, when i let off the throttle the rear wheels locked up causing the car to slide out of control. I pushed on the throttle again to unlock the rear wheels causing me to swerve in the other lane and almost crash into an incoming car. I tried to turn off the brake and could not without stopping the car so i had to skid out of control again stopping to turn it off.
Sep 9, 2026Seat belts, Seats
When putting a car seat in and using the cars seat belt the rear seat belt buckles do not come up at a high enough angle and cause the belt to bind in the buckle for the lap and will not allow the belt to slide and be properly tensioned to hills the car seat to the bottom of the cars seat
Sep 8, 2026Electrical system, Fuel/propulsion system
My 2024 Kia EV6 is experiencing a total failure of the 12V charging system and requires manual jumpstarts to operate. The official ICCU safety recall (SC327) was previously performed, which is why the NHTSA database shows 0 unrepaired recalls for this VIN. However, the manufacturer's remedy has completely failed. Per NHTSA safety guidelines, this vehicle is currently subject to a sudden loss of motive power while driving and is unsafe to operate on public roads.
Jul 20, 2026Electrical system
Car was totally dead even with a 68% charge. AAA came out to jump start. The next day while driving on the highway the car started to lose power. A red warning to check the electrical system came on along with "turtle mode". I was able to pull over off the highway, grateful the two small children were not with me. Car was towed to dealer who kept it for the three days. Only after repeated calling could I reach someone who said they couldn't reproduce the problem. I'm afraid to drive the car at this point as I feel it's just unsafe to do so. This seems to be an ongoing issue that Kia can't seem…
Jul 15, 2026Wheels
Rear tires on my 2024 Kia EV6 wore down to the tire wear-bar limit (2/32" remaining tread) at approximately 19,500 miles, while the front tires on the same vehicle measured roughly double that remaining tread (4/32") at the same odometer reading. The factory-installed tires are rated by the manufacturer for approximately 50,000 miles of tread life under normal use, so reaching the wear-out point on the rear tires alone at roughly 39% of that rated mileage is well outside expected wear for this vehicle at this mileage. This is not an isolated event: numerous other EV6 owners have independently…
Jul 10, 2026Electrical system
We purchased a certified pre-owned 2024 Kia EV6 GT on 6/5/2026. On 6/6/2026 while driving on city streets, the display screen suddenly displayed a large and flashing red warning message "Stop vehicle and check power supply" in addition to the battery symbol. We took the vehicle to the dealership and they diagnosed that the ICCU had failed and needed to be replaced.